Bought new in 1996, w/ 5.8L V8. Now has 190,000 miles. Ran relatively well. Replaced rear differential due to gear oil leak. Replaced also: AC compressor (imploded, costing $1400),radiator (leaked), water pump, alternator, cruise control pressure switch, all hoses and belt, master cylinder and brake booster, battery (twice),CD/radio (twice). Truck had a bad oil leak since 60,000 miles. ABS warning light last year resulted in inability to shift from Park to Drive; and now has the same trouble and I can't drive it -- probably needs to replace the ABS module(cost over $1000 the 1st time). Got stuck one winter in Donner Pass due to a broken special lug nut key -- Tow man raped my wallet.
I bought this vehicle new from dealership. Moved around the country several times with the military, pulling a fully loaded U-Haul trailer each time (maxed out the GVWR for this vehicle). I was surprised by the towing performance since the engine is only 220 HP (5.8L). I never had a complaint with acceleration or stopping performance, even at max GVWR. When not towing, it has OK pickup (it's a truck), and corners about as well as a truck can. Ride is smooth compared to other 4WD trucks, but off-road (I live in the mountains so do a LOT of off-road), the truck is superb. Not a hint of mushiness in the suspension. Not sure how that is (usually you get one or the other, not both).
The F-150 is a tough vehicle with so much cost cutting that it is difficult to see to those roots. The 5.8L is excellent- smooth, quiet, powerful. The 4 speed auto needs an extra gear
desperately but aside from a rough 1-2 shift is smooth and reliable. Brakes are shameful- no feel, squishy and hardly effective. Ergonomics are terrible- unless you are 7 feet tall you will need a broom handle to operate radio and HVAC controls. Good sound system. Quality is poor- panels do not line up, screws often fall out, fit and finish is poor. Drives on the road like an overweight tank should- tries to plow the pavement into submission, resulting in a harsh ride. Fuel economy is around 12 miles per gallon
Truck is solid. I bought this truck as a toy and put long travel with coilovers and have beat the heck out of it. Now it is used to tow my trailer and has never left me stranded. This is the best truck I have ever owned and have no negative comments. The only time this truck has been in the shop is to diagnose the check engine light which ended up being the faulty JET performance chip, do not buy one.
Bought the truck over a year ago with 80,000 miles. Now got 96,000 miles did some work/maintenance on it. Rust is decent but its old. Told to get a manual cause "thats the only good setup with the 4.9," but i hate shifting that thing.
Its slow as hell, and the mpg is about 15 no matter what. The engine is awesome but the M5OD stinks IMO cause it won't last long. Gotta replace all the hydraulic lines, master cylinder, and slave cylinder cause theyre too old and its leaking. Thats about all i gotta do but i can't wait to get a car thats better on gas and aint a pain to shift. Its not really that bad of a truck but I like to vent out about it. ha!