2013 Ford Fusion Hybrid SE 4dr Sedan (2.0L 4cyl gas/electric hybrid CVT)
I've had the 2013 Ford Fusion Hybrid since last November (nearly 10 months) and previously owned a 2010 Fusion Hybrid that I drove for over 3 years. I know how to drive this Hybrid to squeeze every ounce of fuel economy out of it. Driving this car for maximum efficiency, with 100% efficiency on Braking, Acceleration & Cruising resulting in an average 33 MPG.
It was physically impossible to operate this vehicle under any conditions to get more than 35 MPG.
The dealer told me it needed a 5k mile "break-in". So I waited and drove.
After 5k - NO change whatsoever in MPG. Then they installed a new "Fix" for the MPG the Ford released and now my MPG is WORSE!
Now I can barely get 30 MPG!
Looks and rides well.
MPG is far less than advertised.
The electric drive component is vastly improved over the previous model Fusion Hybrid, but the Gas Engine, even though smaller, is actually Far less efficient.
At common speeds of 40-55 MPH, the 2.0 ltr gas engine in the 2013 model gets less than Half the MPG of the previous 2.5 ltr engine. The net result is actually slightly worse MPG than the previous model, when Ford claims it gets substantially better. Ford needs to fix the Gas Engine portion of this Hybrid drive train.
I have a 2013 Ford Fusion Hybrid, and I generally love it. I never expected to get 47MPG - I think everyone knew that wasn't realistic.
From April 2013 until October 2013, I was averaging around 39.x MPG overall (according to the car's computer). I commute 110 miles round trip, three days a week, or around 25K miles per year, mostly on the highway at 75 MPH. So I wasn't too unhappy with 39 overall. On some trips home from work (55 miles), I was getting 42 MPG when I drove conservatively. Then in October, I accepted the Ford "fix" that changed the algorithm for when EV mode could kick in. Previously, EV mode went up to 62 MPH. After the fix, EV mode could go up to something like 80 MPH. In theory, that would give highway drivers better gas mileage, if the engine could switch to EV at higher speeds. And it was indeed the case that I saw the engine occasionally switch to EV mode at the higher speeds, so that part worked.
However, after I accepted the fix, my overall gas mileage started to decrease. I have a very consistent driving route and conditions. Each time when I stopped the car, I looked at the mileage for that trip, and the numbers were lower than before the fix was applied. This continued for the next 5 or 6 weeks. I mentioned it to the Ford dealer shop and they said to keep an eye on it. Well, after the weather started getting really cold in November and beyond, the mileage decreased even further, but that always happens with hybrids (and most cars) in the winter - the battery isn't as efficient in cold weather, you run the defrost and heat more, you let the car warm up, etc. So I couldn't really prove after that what was due to the Ford algorithm "fix" and what was due to the cold weather conditions. This has been a particularly cold, harsh winter, and now my overall gas mileage is down to 36.9 MPG (according to the car's computer).
I haven't tried the manual gas mileage calculations, partly because I think there are so many variables in that process. The Car and Driver article linked elsewhere refers to them: how full do you fill your tank each time? how do you know how full it is when different gas pumps are calibrated to cut off with different amounts of back pressure? what about different manufacturers of fuel? differences between summer and winter fuel? heat and cold? The article suggested a particular approach to try to minimize some of the variables, but I'm not usually able to be that consistent, so I end up relying on the car's computer numbers.
I am biding my time until warmer weather an more optimal driving conditions return. Then I plan to consistently measure my MPG again and see if it goes back up closer to what it was before the fix. I do plan to go back to the dealer and keep this issue in front of them. They seemed sympathetic, but they are limited in what they can do. I would like to hear from any other 2013 Ford Fusion Hybrid owners who have accepted the EV mode "fix" and to hear the experience of others gas mileage after that.
I have the exact same issue with my 2013 Lincoln MKZ.
I brought it in and they did the upgrade and now I can't get over 36 MPG.
I was getting between 39 and 40 prior.
It doesn't seem like I can even keep it in electric anymore unless the electric guage is passed 1/2 full.
† Edmunds.com received the highest numerical score in the proprietary J.D. Power 2014 Third-Party Automotive Website Evaluation Study℠. Results based on responses from 3,381 responses, measuring 14 companies and measures third-party automotive website usefulness among new and used vehicle shoppers. Proprietary study results are based on experiences and perceptions of owners surveyed from January 2014. Your experiences may vary. Visit jdpower.com.