Have You Considered...

2004 Chevrolet Express Consumer Discussions

All Chevrolet Express Models

Used TMV from $6,204

adding external tach to Express 3500?

  • adding external tach to Express 3500?

    Written by: shardey on Oct 6, 2011 10:27:36 PM

    Has anyone ever added an external tachometer to a 2004 Chevy Express, with a 6.0? If so, any tips or hints or directions? Much appreciated!

Chevy Express/GMC Savana: Brakes

  • Re: Severe Vibration while Braking on Grade [gmcustsvc]

    Written by: workvan3 on Oct 28, 2010 7:20:19 PM

    I have a 2004 Chevy Express 3500 with the same problem. I have driven the van since new and it now has approx 42,000 miles. I had the discs turned a couple years ago. On only two certain hills in our area, when I have to pump the brakes, a slight vibration will start and increase with each pump until the steering wheel shakes uncontrollably. This is a dangerous and severe ... Read More

Chevy Express/GMC Savana

  • Re: Hump on floor in back of passenger seat in 2004 savana? [ffrrggyy]

    Written by: gpturner on Jun 19, 2008 2:23:23 AM

    I have a 2007 Chevy Express Basically the exact same van that exact same bump has bothered me from day one. It has always been there and is supposed to be ....sorry

Chevy Express Interior and Trim Issues

  • Re: Armrest on Bench seat of 2004 Chevy Express Van [mowerseller]

    Written by: tumbleweed58 on Oct 1, 2009 4:36:49 PM

    i had this problem on a ford van , and could be the same thing. as for tighten it i don't think so but there is a way of rotating the arm and there should be a place where the arm will slid forward and taking it off the hinge. Also you can go to www.vannin.com and its a site for van problems and vanning in general. hope that this has ... Read More

Have a 2004 Chevy Conversion van by American Luxury Coach

  • Have a 2004 Chevy Conversion van by American Luxury Coach

    Written by: creedandval on Jun 28, 2009 1:58:20 PM

    that is a G3500 Express and only has 42,000 miles on it. How would I find out what the van is worth in order to sell it? Kelly Blue Book and Nada are of no help at all. Thanks everyone.

Chevy Express/GMC Savana

  • HELP!!

    Written by: ryanmcirish on Dec 23, 2007 12:42:05 PM

    Hi all, I'm working on a 2004 Chevy Express 3500, and the instrument panel gauges have died. When the car starts up, the arrows wiggle a little, and the alternator gauge goes to normal, then they all quit. the panel still lights up, and shows the prnd, but no little underline bar to tell you what gear you're in, and the odometer is no longer adding miles. The check gauges light ... Read More

Chevy Express/GMC Savana Owners: Meet the Members

  • Re: New Owner [newsie23]

    Written by: jgarnaas on Aug 6, 2008 10:07:57 AM

    I can look in my factory service manuals to see if the seats your looking for would fit your vehicle.give me some time to look into it..From 96 on when the new chevy chassis was introduced there has been little change in many aspects of the vehicle.In 2004 the stabilitrac was introduced into the vehicle.Glad i just happened to buy a used o4.Im still learning the variouse vehicle model codes such ... Read More

Chevy Express/GMC Savana

  • Re: hi mile express [eandlcubed]

    Written by: jjpdickson on Apr 15, 2007 9:33:39 PM

    In 2004 I purchased a 2001 Chevy express 3500 with 74000 miles from Enterprise. It has 14 bucket seats. I'm very happy with it. Drove it to upstate N Y and back from Los Angeles with no problems. I did have to repair a rear axle seal leak recently. It will cruise all day long at 80 mph with 10 people. It can get up to 15 mpg on the road. ... Read More

Chevy Express Interior and Trim Issues

  • Armrest on Bench seat of 2004 Chevy Express Van

    Written by: mowerseller on Mar 14, 2007 4:21:31 AM

    The arm rest on Pass side of the front Bech seat is real loose, no zippers on it. What can be done to tighten it? How do you take it off?

Chevy Express/GMC Savana

  • Towing Question

    Written by: klandy on Oct 26, 2005 7:01:50 PM

    Hello all! Forgive me for sounding stupid but I just can't figure out how much I can haul? I went to the chevy web site but all I found was figures for 2005 models with VORTEC engines. And I have no idea what a vortec engine is compaired to what is in mine. all I know is that I have a 2004 Express Work Van (HD) with a 4.8L V8 engine ... Read More

Conversion Van Pricing

  • Re: 2004 Chevy Express Conversion [tim15]

    Written by: steve_ on Mar 9, 2005 8:29:41 PM

    Will it still loose half its value in two years? It might - heck, lots of normal cars lose 40% of their value in a couple of years. I talked to two couples the other day at an interstate rest area from BC who were convoying in two fancy conversion vans. They seemed to really be enjoying themselves. Steve, Host

  • 2004 Chevy Express Conversion

    Written by: tim15 on Mar 9, 2005 6:57:13 PM

    I am considering purchasing a brand new 2004 Chevrolet Express with a low top Chariot conversion. Van has leather and dvd and dual doors. The van has been on the lot for over a year. The sticker is 42K, and I have them down to 29,500.00. Is this a good deal? Will it still loose half its value in two years? I've never owned a comversion van, so any tips would ... Read More

Chevy Express/GMC Savana

  • Savana in Twin Recalls

    Written by: steve_ on Feb 25, 2005 12:52:51 PM

    "GMC's Savana full-size, rear- or four-wheel-drive van is the subject of two recalls, the National Highway Traffic Safety Administration has announced. The GMC van and its Chevy Express counterpart are being recalled first for a problem with a hydraulic fluid pump under the hood. If it fails and the hood is open, fragments could hurt people standing nearby; when driving, it could affect power braking and steering. Some 155,000 vehicles, including ... Read More

Chevy Venture Owners: Meet the Members

  • New to The Astro/Safari Line

    Written by: john29 on Aug 8, 2004 12:31:11 PM

    Found a 2004 Express 3500, I had wanted for a long time. It was in Ruidoso, NM. A 2004 with 6750 miles and a good price of $19,200. I researched the model and found that they were only getting 11-13 MPG. This kinda turned me off cause I had a 90 dodge 3500 van and it got 18mpg.    Ended up looking at astro/safari and found an almost new Safari and am ... Read More

Chevy Express/GMC Savana

  • no title

    Written by: steve_ on Jun 22, 2004 10:31:47 PM

    Follow-Up Test: 2004 Chevrolet Express 3500 Steve, Host

Research Models

Advertisement

Advertisement

Advertisement

Advertisement

Recently Viewed

    Select your vehicles